N.S. vessel overloaded with fish, fuel, ice and freshwater at time of sinking: TSB

The Transportation Safety Board says a fishing vessel that went down off the coast of Nova Scotia in 2018 wasoverloaded with fish, ice, fuel and freshwater, leading to its sinking.

In itsinvestigation report released Wednesday, the boardsaid the Atlantic Sapphire should have been carrying no more than 41 long tons of cargo.

When it sank around 11 p.m.on Dec. 13, 2018, the trawler was loaded with over 60 long tons, putting it about 46 per cent over capacity. Onelong ton is the equivalent of about 1,016 kilograms.

"On the occurrence voyage, the crew caught a full load of fish in less time than on any other trip that year, so there was more fuel, freshwater, and ice on board than usual," the report said.

"The crew did not appreciate the risk to the vessel's stability created by this excess weight, and as a result, the crew did not take precautions against the risk of downflooding and capsizing."

Vessel was overloaded before last catch

Based on evidence collected after the sinking, including interviews with the three-person crew all of whom were rescued by another fishing boat the board determined the boat was already overloaded when the crew hauled in a finalcatch of haddockweighing seven long tons.

Sea conditions caused a "slight rolling motion," which was enough to bring water onto the main deck, which then cascadedinto the fish hold through an open hatch.

The crew was busy loading the final catch into pens below deck when the 18.6-metre fibreglass vessel first starting taking on water, so "the situation was not recognized until the fish hold began to downflood," the report said.

Capacity guidelines ignored

Investigators found the cargo limit for the Atlantic Sapphire was laid out by Transport Canada in a "stability booklet" that was available to crew members, saidtheyhadn't consulted the information in at least a year.

Up until its sinking, ignoring those guidelines hadn't had "any apparent impact on safety, indicating that an adaption to the loading procedure had likely evolved over time," the report said.

The report added that the boat's owner, Nova's Finest Fisheries Inc.of Middle West Pubnico, N.S., hadn't been ensuring compliance with the capacity guidelines.

"Consequently, the risks associated with the loading practices on the day of the occurrence, particularly given the extra freshwater and fuel on board, were not fully appreciated by the crew," it said.

Nova's Finest Fisheries has not responded to CBC's request for comment on the board's findings.

Work-rest requirements not met

Theinvestigation also found the crew hadn't been meeting the work-rest schedule required by federal regulations. Those requirements, the report said, would have been challenging for any three-person crew to accomplish.

"When meeting the regulatory requirements with a crew of three, the time remaining for fishing operations is minimal: about four hours with twocrew on deck and another threehours with onecrew on deck," the report said.

"Such a minimal amount of time allocated to fishing is not feasible in mostoperations."

The board pointed out that Nova Scotia has no provincial regulations for fishing vessel operations, nor a minimum crew complement. In 2020, the board identified the need for co-ordinated regulatory oversight between the federal government and provinces as a key safety issue.

When asked if the province is formulating or consideringregulatory change in light of the board's findings,aspokesperson from the Nova Scotia Department of Labour said transportation vessels and crew complement do not fall within the scope of provincial legislation.

"The [Nova Scotia Occupational Health and Safety] Act focuses on the safety of employees, including areas of training, safe equipment operation and the use of personal protective equipment, which includes personal floating devices," Shannon Kerr said by email.

Kerr said the Occupational Health and Safety division "continues to collaborate with our regulatory counterparts, including the Transportation Safety Board of Canada, to address safety in the fishing sector."